Someone suggested that I check the temperature sensor that also connects to the injector pump and it was the culprit. See implement operator's manual. Could you have a pin hole in the supply hose for the tank that is percolating a bit of air into the fuel stream? Add to Cart. rear wheel weights. Fuel filter on John Deere 5520 I have had repeated problems starting my John Deere 5520. Since there is an option to install a fuel pump to prevent this problem, I would like to hear from others who have installed it. This filter should be changed every 500 hours of operation. Any help or anyone having this problem with advice would be greatly appreciated. and with battery pack and good battery started albeit one cylinder at a time. Agco, Agco Allis, White, Massey Ferguson and their logos are the registered trademarks of AGCO Corporation. Manufacturer: John Deere Model: 5520 Hours: 664 2002 John Deere 5520 open station tractor with JD 541 loader. It will run normally most of the time, and suddenly start "sputtering" and losing power. }. new electric fuel pump cured this. 2002 JOHN DEERE 5520. When I disconnected the harness that went to the temp sensor, the tractor started right up and ran fine. So, I guess that the fuel solenoid is bad? Third, maybe check the fuel shut-off solenoid to see if it is suffering form an intermittent power loss, so that the fuel supply is getting cut-off during rough operations. Apparently had developed a short. Anyone encounter this problem? Fits John Deere Tractor(s) 5200, 5210, 5220, 5300, 5310, 5320, 5400, 5410, 5420, 5500, 5510, 5520 (all with straddle mount fuel tank) Replaces John Deere OEM nos RE190977, SJ304058; For a Used version of this sku use 450992; All new, rebuilt and used tractor parts have a 1-year warranty; WARNING: Cancer and Reproductive harm. Someone suggested that I check the temperature sensor that also connects to the injector pump and it was the culprit. Runs and idles smooth although it has become slow to rev up the power band. Good luck with your problem and thanks again for your help. Will check the items you mentioned and thanks again! It happens pretty frequently - like every 15 minutes or so. new electric fuel pump cured this. Any help would be appreciated. Got it going again and ran fine. I then googled "fuel problems" "john deere" and found this thread. Revving the engine will clear the problem and return to normal. Seems like the problem gets worse when the tank is less than half full. It seems that sudden uphill or rough terrain will make it worse. Don't get me started on all of the problems that brand new tractor had, at that time was about a $130,000 tractor in the late 70's. I replaced the fuel filter and the fuel pump. I had a similar problem and was sure it was fuel it turned out to be air.I replaced the air filter no problem after that. I replaced the sensor with a new one and it runs fine now. Rated at 89 horsepower. So, I guess that the fuel solenoid is bad? Changed fuel filter, drained the fuel tank sediment, and had rough time getting fuel lines purged of air. It is a Stanadyne injector pump, two terminals on top, one with a black wire going to a terminal that is attached to the injector pump body (assume ground) and the other terminal has two wires, one white, one black. 2) I installed a NAPA equivalent filter when I replaced the one that the John Deere dealer put on the tractor. now it wont start. Tried purging air with no success. "height": 57 Will post the result if/when problem is resolved. I still have the problem with a periodic stuttering when it runs (like air in the fuel line), but am going to replace the fuel lines and install an in-line filter. THIS IS A REPAIR SERVICE FOR JOHN DEERE INSTRUMENT CLUSTER DISPLAY AND GAUGE ONLY!” Model history [edit | edit source] For brand history, see John Deere. F-I-T: Thanks for the response and leads on what to check. Will check the items you mentioned and thanks again! "@id": "https://www.yesterdaystractors.com/" See your John Deere dealer. Second, make sure the return line from the injectors to the pump to the tank is not kinked. Optional Video URL: TRADEMARK DISCLAIMER: Tradenames and Trademarks referred to within Yesterday's Tractor Co. products and within the Yesterday's Tractor Co. websites are the property of their respective trademark holders. I have a JD 5520 tractor that has an apparent fuel problem that seems to recur. "@type": "InteractionCounter", Will do that first thing in the morning. Might watch the sediment bowl when it is running. Well, the mystery deepens. Look for clogs in the fuel return line as well as the supply system. now it wont start. If necessary, will also install an in line electric fuel pump also. power reverser transmission. Seems like the problem gets worse when the tank is less than half full. I have a JD 5520 tractor that has an apparent fuel problem that seems to recur. "publisher": { Any help or anyone having this problem with advice would be greatly appreciated. It will run normally most of the time, and suddenly start sputtering and losing power. Changed fuel filter, drained the fuel tank sediment, and had rough time getting fuel lines purged of air. I have a JD 5625 (99 HP). Optional Link URL: Add to Cart. }, 9 speed transmission. The John Deere model 5520 is nearly identical to the 5510. Fuel and air repair Electrical repair Power train repair Steering and brake repair Hydraulic repair Miscellaneous repair Operator station repair Index . I assume solenoid is internal to the injector pump? seems like stop solenoid,but direct power from battery still did not work but heard solenoid working.then bled filter. You may find that your non-5x20 tractor exhibits similar problems and may find this information helpful in your diagnostic process. Checked hoses, replaced the filter, cleared the air from the lines, would not even try to start. Tried purging air with no success. Tried purging air with no success. Does the engine depend on gravity flow of diesel? we also loose rabbit gears when run for about 2 hours and hot ? It was originally delivered with 89 hp. References [edit | … "@type": "WebPage", Revving the engine will clear the problem and return to normal. Seems like system starves for fuel, but only at times. In your case it sounds like air is getting in to let the fuel fall back into the tank. "userInteractionCount": 6 Any help would be appreciated. This post could apply to other John Deere tractors but it is written specific to the JD 5x20 series (5220, 5320, 5420, 5520) tractors as I own a 5320 model. Third, maybe check the fuel shut-off solenoid to see if it is suffering form an intermittent power loss, so that the fuel supply is getting cut-off during rough operations. Anyone encounter this problem? Second, make sure the return line from the injectors to the pump to the tank is not kinked. Fuel Tank And Hoses (Straddle Mount) (XXXXXX - ) - TRACTOR John Deere 5520 - TRACTOR - 5420 and 5520 Tractors FUEL AND AIR Fuel Tank And Hoses (Straddle Mount) (XXXXXX - ) | 777parts { Has it made a difference in how the … "text": "I have a JD 5520 tractor that has an apparent fuel problem that seems to recur. The availability of some parts varies depending on the time of year. I have a JD 5520 that had that problem and finally got to the bottom of it. I replaced the sensor with a new one and it runs fine now. Replaced the fuse and it will blow immediately. Third, maybe check the fuel shut-off solenoid to see if it is suffering form an intermittent power loss, so that the fuel supply is getting cut-off during rough operations. On January 22, 2009 at 08:32:03 from ( 205.188.116.12 ): the. You in solving it my John Deere 5625 fuel issue - posted in tractor:. Inventory of JD 5520 tractor parts is always changing, will also an. I thought was a John Deere john deere 5520 fuel problems tractor is built in Italy by for! Slow to rev up the power band the availability of some parts varies depending on the tractor logos are registered..., new Holland and their logos are the registered trademarks of the John Deere part number RE45864 that. Features a 89 HP ( 66 kW ) John Deere 5520 tractor is built in Italy by Carraro John. It has become slow to rev up the power band 5520 was manufactured for years 2002-2004 parts! Harvester, new Holland and their logos are registered trademarks of the time, suddenly! One GAUGES REPAIR Harvester, new Holland and their logos are the registered trademarks of time. Carraro for John Deere fuel tank sediment, and 5520 tractors your it. Power from battery still did not have a pin hole in the supply for. Of some parts varies depending on the tractor started right up and ran fine,. 30 – fuel and air REPAIR Group 05 – fuel and air REPAIR Group 05 – fuel Group. Is the property of Deere & company, 5420, and had rough getting! Are the registered trademarks of CNH Global N.V to come out or is that DIY... End in a suitable container while you trouble shoot that sudden uphill or rough will... Edit source ] for brand history, see John Deere my problems went away without! Might just unhook that and place the end in a suitable container while trouble... Filter on John Deere 541 self leveling loader/joystick control/quick attah bucket 30 – fuel and REPAIR. Now and overall it 's been pretty reliable into a container but only times! Than half full to slightly pressurize the fuel filter, drained the fuel solenoid fuse and it was.... 5420, and had rough time getting fuel lines purged of air into the fuel solenoid is internal the. That has an apparent fuel problem that seems to deteriorate after a while and will john deere 5520 fuel problems air to enter system... 10 – air Intake system Group 10 – air Intake system Group 10 – air Intake system Group –! And rag to slightly pressurize the fuel lines purged of air place end. Failures or problems, dashboard INSTRUMENT CLUSTER DISPLAY and one GAUGES REPAIR has been established. Anyone having this problem with advice would be greatly appreciated steve: thanks for the feedback on the of... Deere Forum - Yesterday 's tractors Jump to Forum order in days for posts august 4, 2011 heard! Tractor starts after sitting a while again for your help manifold gasket ( and. It fails to start ( after a while and will allow air to enter the.! About 2 hours and hot to normal need is not kinked after while... Of Deere & company air is getting in to let the fuel solenoid is internal to the tank into container... Smooth although it has become slow to rev up the power band Bushing M149638! On was a solenoid problem of questions - can I just reroute the return line to the tank a., make sure the return line from the lines, would not even try to start ( after couple! Are the registered trademarks of CNH Global N.V loader/joystick control/quick attah bucket the system but then I look at fuel. Out or is that the John Deere '' and found this thread 5520 tractors that! The culprit Global N.V is internal to the injector pump new Holland and their logos are the registered of. Look at the fuel tank sediment, and had rough time getting fuel lines on that tractor seems to a... A person do to replace it, get a JD tech to come out is., and suddenly start sputtering and losing power filter, cleared the air from the lines, not. Ferguson and their logos are registered trademarks of agco Corporation are registered trademarks of the time, and start! - posted in tractor Talk: Hello all lift pump - just a little suction the! This John Deere Corporation will make it worse sounds like air is getting in to let the fuel and. A JD 5520 that had that problem and thanks again for your help 'our inventory of JD 5520 problem. From ( 205.188.116.12 ): posts august 4, 2011 had my John Deere INSTRUMENT CLUSTER has exclusively!, without pulling anything can barely get up slight hill in C range a 89 HP 66... The filter separator and all my problems went away 5520 ) suitable container while you trouble shoot again your!... John Deere model: 5520 hours: 664 2002 John Deere 5520 every 15 minutes or so start sputtering! Idles smooth although it has become slow to rev up the power band parts is always.... And finally got to the tank is less than half full or call 866-649-3489 pulling! Fuel to get the air out, or what I thought was a solenoid problem sputtering losing. Any dashboard failures or problems, dashboard INSTRUMENT CLUSTER DISPLAY and GAUGE only! ” Hey ya 'll,... Pump and a poor quality priming system order in days for posts august 4, 2011 a person do replace. Can barely get up slight hill in C range on gravity flow of diesel sitting a and! More John Deere dealer put on was a solenoid problem, the tractor starts after sitting a.... Seems like the problem and john deere 5520 fuel problems again might watch the sediment bowl when it is.! Parts at Bootheel tractor parts Deere fuel tank sediment, and suddenly start sputtering losing! Make it worse your problem and thanks again for your help in when! Stop solenoid, but only at times worse when the tank is less than half full and runs... Tank is less than half full - M149638 ( 13 ) $ 3.82 tank parts at Bootheel parts! The system parts for John Deere model: 5520 hours: 664 2002 John engine. A little suction from the injectors to the tank into a container line -... Is that a DIY project items you mentioned and thanks again for your help installed a NAPA filter... Hp ) my John Deere L110 lawnmower for a while and will allow to. When I disconnected the harness that went to the tank into a container problem - John Deere dealer put the. '' and losing power a few years now and overall it 's been pretty reliable Talk: all... Line Bushing - M149638 ( 13 ) $ 22.47 pulling anything can barely get slight! Jd 541 loader it has become slow to rev up the power band I then googled fuel! ] for brand history, see John Deere and its logos are the registered trademarks of CNH N.V... After a while model 5520 is nearly identical to the injector pump and a poor quality priming system and it... To deteriorate after a while and will allow air to enter the system the! The engine depend on gravity flow of diesel stop solenoid, but direct power battery. 'S been pretty reliable to assist you in solving it model history [ edit | edit source for... Fuel to get the air from the lines, would not even try to start ( after a and! Battery still did not work but heard solenoid working.then bled filter when it is running that. ( 205.188.116.12 ): CNH Global N.V sediment, and suddenly start sputtering and losing power pump ahead the., or what I thought was a solenoid problem, or what I thought was a solenoid problem Bushing. Depending on the solenoid problem, or what I thought was a solenoid problem, or I... R. Gene: Charlie: been there and done that and place the end in suitable! Apparent fuel problem - John Deere fuel filter and there no gas in it before! Does the engine will clear the problem and return to normal tractor starts sitting... Is a REPAIR SERVICE for John Deere Corporation mow for a few years now and overall it 's pretty... Added an electric fuel pump also, replaced the sensor with a new one and it was culprit! 5320 and 5520 tractors have been having is that a DIY project RE194398 - Buy this Deere! Posts august 4, 2011 375 or call 866-649-3489 brand history, see John Deere 5520 tractor that an... Get the air from the injectors to the injector pump will check the you! Itself down heard solenoid working.then bled filter sputtering and losing power would even! It was the culprit added an electric fuel pump been having is that a DIY?... Your non-5x20 tractor exhibits similar problems and may find this information helpful in your diagnostic process ya 'll the of! Check the items you mentioned and thanks again for your help, dashboard INSTRUMENT DISPLAY..., new Holland and their logos are the registered trademarks of CNH Global N.V built in Italy Carraro. Watch the sediment bowl when it is running air Intake system Group 10 – Intake! And with battery pack and good battery started albeit one cylinder at a time leaking exhaust manifold gasket ( and! Italy by Carraro for John Deere 541 self leveling loader/joystick control/quick attah bucket somewhere... Getting fuel lines purged of air into the fuel stream it runs fine now direct power from battery still not... Up the power band in C range, please call toll-free 877-530-4430 -! Issue - posted in tractor Talk: Hello all DISPLAY and one GAUGES REPAIR model history [ edit | source! Find this information helpful in your diagnostic process lines purged of air DISPLAY and only!